Lenovo IdeaPad Y480 Bedienungsanleitung

Lenovo Y480/580Hardware MaintenanceManual

Lenovo Y480/Y580 Hardware Maintenance Manual6Any computer part containing transistors or integrated circuits (ICs) should be considered sensitive to e

Lenovo Y480/Y580 Hardware Maintenance Manual96Table 11. Parts list—3-pin power cords (continued)Region P/N CRU IDBrazil• Longwell LP-46+H03VV-F+LS-18

Lenovo Y480/Y58097Table 11. Parts list—3-pin power cords (continued)Region P/N CRU IDKorea• VOLEX M2511+KETI IEC+VAC5S 1m145000533 *Australia• VOLEX A

Lenovo Y480/Y580 Hardware Maintenance Manual98Lenovo may not offer the products, services, or features discussed in this document in all countries. Co

Notices99Any performance data contained herein was determined in a controlled environment. Therefore, the result obtained in other operating environme

Safety information7The safety notices in this section are provided in English, French, German, Hebrew, Italian, Japanese, and Spanish.Safety notices:

Lenovo Y480/Y580 Hardware Maintenance Manual8Safety notice 2DANGERSome standby batteries contain a small amount of nickel and cadmium. Do not disassem

Safety information9Safety notice 3DANGERThe battery pack contains small amounts of nickel. Do not disassemble it, throw it into fire or water, or shor

Lenovo Y480/Y580 Hardware Maintenance Manual10Safety notice 4DANGERThe lithium battery can cause a fire, an explosion, or a severe burn. Do not rechar

Safety information11Safety notice 5If the LCD breaks and the fluid from inside the LCD gets into your eyes or on your hands, immediately wash the affe

Lenovo Y480/Y580 Hardware Maintenance Manual12Safety notice 6DANGERTo avoid shock, do not remove the plastic cover that protects the lower part of the

Safety information13Safety notice 8DANGERBefore removing any FRU, turn off the computer, unplug all power cords from electrical outlets, remove the ba

Lenovo Y480/Y580 Hardware Maintenance Manual14Some models of Lenovo computer are equipped from the factory with an optical storage device such as a CD

Safety information15A CD-ROM drive, a DVD-ROM drive, or any other storage device installed may contain an embedded Class 3A or Class 3B laser diode. N

Note:Before using this information and the product it supports, be sure to read the general information under “Notices” on page 98.First Edition (Marc

Lenovo Y480/Y580 Hardware Maintenance Manual16This chapter presents the following important service information:• “Strategy for replacing FRUs” on pag

Important service information17Use the following strategy to prevent unnecessary expense for replacing and servicing FRUs:• If you are instructed to r

Lenovo Y480/Y580 Hardware Maintenance Manual18RoHS, The Restriction of Hazardous Substances in Electrical and Electronic Equipment Directive (2002/95/

General checkout19This chapter presents the following information:• “What to do first” on page 20• “Power system checkout” on page 21Before you go to

Lenovo Y480/Y580 Hardware Maintenance Manual20When you do return an FRU, you must include the following information in the parts exchange form or part

General checkout21To verify a symptom, follow the steps below:1. Turn off the computer.2. Remove the battery pack.3. Connect the AC adapter.4. Make su

Lenovo Y480/Y580 Hardware Maintenance Manual22Perform operational charging. If the battery status indicator or icon does not light on, remove the batt

Related service information23This chapter presents the following information:• “Restoring the factory contents by using Recovery Disc Set” on page 23•

Lenovo Y480/Y580 Hardware Maintenance Manual247. When all of the data has been copied from the last disc in the set, remove the disc and restart the c

Related service information25Note: Power management modes are not supported for APM operating system.To reduce power consumption, the computer has thr

iiiAbout this manual...ivSafety information...1General safety ...

Lenovo Y480/Y580 Hardware Maintenance Manual26Hibernation modeIn hibernation mode, the following occurs:• The system status, RAM, VRAM, and setup data

Lenovo Y480/Y58027This chapter presents the following product-specific service references and product-specific parts information:• “Specifications” on

Lenovo Y480/Y580 Hardware Maintenance Manual28Table 1. Specifications (continued)Feature DescriptionHard disk drive • 500GB, 5400rpm (7mm)*• 500GB, 54

Lenovo Y480/Y58029Table 1. Specifications (continued)Feature DescriptionFinger Print Reader•N/AIntegrated camera•HD CameraBattery • 6 cells, 3400mAH o

Lenovo Y480/Y580 Hardware Maintenance Manual30The system status indicators below show the computer status:Status indicatorsedcba

Lenovo Y480/Y58031Table 2. Status indicatorsIndicator MeaningTouchpad White: The touchpad is disabled.Battery statusBlinking amber: (500ms off/1s on)

Lenovo Y480/Y580 Hardware Maintenance Manual32The following table shows the function of each combination of Fn with a function key.Table 4. Fn key com

Lenovo Y480/Y58033This section presents notices related to removing and replacing parts. Read this section carefully before replacing any FRU.Screw no

Lenovo Y480/Y580 Hardware Maintenance Manual34This section presents exploded figures with the instructions to indicate how to remove and replace the F

Lenovo Y480/Y580351010 Battery packFigure 1. Removal steps of battery packUnlock the manual battery latch . Holding the spring-loaded battery latch i

ivThis manual contains service and reference information for the following Lenovo product:IdeaPad Y480/Y580Use this manual to troubleshoot problems.Th

Lenovo Y480/Y580 Hardware Maintenance Manual361020 Dummy cardFor access, remove this FRU:• “1010 Battery pack” on page 35Figure 2. Removal steps of du

Lenovo Y480/Y580371030 Hard disk drive(HDD)/Memory/Mini PCI Express Card slot compartment coverFor access, remove this FRU:• “1010 Battery pack” on pa

Lenovo Y480/Y580 Hardware Maintenance Manual381040 Hard disk driveFor access, remove these FRUs in order:• “1010 Battery pack” on page 35• “1030 Hard

Lenovo Y480/Y58039Pull the tab in the direction shown by arrow .Take out the hard disk drive secured in a metal frame .When installing: Make sure th

Lenovo Y480/Y580 Hardware Maintenance Manual401050 Optical driveFor access, remove this FRU:• “1010 Battery pack” on page 35Figure 5. Removal steps of

Lenovo Y480/Y580411060 DIMMFor access, remove these FRUs in order:• “1010 Battery pack” on page 35• “1030 Hard disk drive(HDD)/Memory/Mini PCI Express

Lenovo Y480/Y580 Hardware Maintenance Manual421070 PCI Express Mini Card for wireless LAN/WAN and TV CardFor access, remove these FRUs in order:• “101

Lenovo Y480/Y58043Figure 7. Removal steps of PCI Express Mini Card for wireless LAN/WAN and TV Card (continued)When installing:• In models with a wire

Lenovo Y480/Y580 Hardware Maintenance Manual441080 KeyboardFor access, remove this FRU:• “1010 Battery pack” on page 35Figure 8. Removal steps of keyb

Lenovo Y480/Y58045Figure 8. Removal steps of keyboard (continued)Y580: Remove the screws .Step Screw (quantity) Color TorqueM2.5 × 8 mm, flat-head, n

Safety information1This chapter presents the following safety information that you need to get familiar with before you service a Lenovo computer:• “

Lenovo Y480/Y580 Hardware Maintenance Manual46Figure 8. Removal steps of keyboard (continued)Y580: Loosen the keyboard with fingers in the direction s

Lenovo Y480/Y580471090 Keyboard bezelFor access, remove these FRUs in order:• “1010 Battery pack” on page 35• “1030 Hard disk drive(HDD)/Memory/Mini P

Lenovo Y480/Y580 Hardware Maintenance Manual48Figure 9. Removal steps of keyboard (continued)Y580: Remove twelve screws , four screws and three scr

Lenovo Y480/Y58049Figure 9. Removal steps of keyboard bezel (continued)Y480: Detach the power board connector and TouchPad cable in the direction show

Lenovo Y480/Y580 Hardware Maintenance Manual50Figure 9. Removal steps of keyboard bezel (continued)Remove the keyboard bezel in the direction shown by

Lenovo Y480/Y580511100 System boardFor access, remove these FRUs in order:• “1010 Battery pack” on page 35• “1020 Dummy card” on page 36• “1030 Hard d

Lenovo Y480/Y580 Hardware Maintenance Manual52Figure 10. Removal steps of system boardY480: Loosen the screws . Unplug LCD, USB, Power, speaker, blue

Lenovo Y480/Y58053Figure 10. Removal steps of system boardY580: Loosen three screws . Unplug LCD, USB, Power, speaker connectors in the direction sho

Lenovo Y480/Y580 Hardware Maintenance Manual54Figure 10. Removal steps of system board (continued)Remove the system board in the direction shown by ar

Lenovo Y480/Y580551110 LCD unitFor access, remove these FRUs in order:• “1010 Battery pack” on page 35• “1020 Dummy card” on page 36• “1030 Hard disk

Lenovo Y480/Y580 Hardware Maintenance Manual2Follow these rules below to ensure general safety:• Observe a good housekeeping in the area where the mac

Lenovo Y480/Y580 Hardware Maintenance Manual56Figure 11. Removal steps of system board (continued)Y580: Release the antenna cables from the cable guid

Lenovo Y480/Y58057Figure 11. Removal steps of system board (continued)Remove the LCD unit in the direction shown by arrows .ccc

Lenovo Y480/Y580 Hardware Maintenance Manual581120 Fan assembly and Heat Sink assemblyFor access, remove these FRUs in order:• “1010 Battery pack” on

Lenovo Y480/Y58059Figure 12. Removal steps of fan assembly and heat sink assemblyDetach the fan connector in the direction shown by arrow and loosen

Lenovo Y480/Y580 Hardware Maintenance Manual601130 CPUFor access, remove these FRUs in order:• “1010 Battery pack” on page 35• “1020 Dummy card” on pa

Lenovo Y480/Y580611140 Base cover, speakers and bluetooth cardFor access, remove these FRUs in order:• “1010 Battery pack” on page 35• “1020 Dummy car

Lenovo Y480/Y580 Hardware Maintenance Manual62Figure 14. Removal steps of base cover and bluetooth card (continued)Y580:Y480: Loosen the screw , then

Lenovo Y480/Y58063Figure 14. Removal steps of base cover and bluetooth card (continued)Y580: Remove the power assembly in the direction shown by arrow

Lenovo Y480/Y580 Hardware Maintenance Manual64Note: Applying labels to the base coverThe new base cover FRU is shipped with a kit containing labels of

Lenovo Y480/Y580651150 LCD front bezelFor access, remove these FRUs in order:• “1010 Battery pack” on page 35• “1020 Dummy card” on page 36• “1030 Har

Safety information3Observe the following rules when working on electrical equipments.• Find the room emergency power-off (EPO) switch, disconnecting s

Lenovo Y480/Y580 Hardware Maintenance Manual66Figure 15. Removal steps of LCD front bezel (continued)Remove the LCD front bezel in the direction shown

Lenovo Y480/Y580671160 LCD panel, LCD cable and hingesFor access, remove these FRUs in order:• “1010 Battery pack” on page 35• “1020 Dummy card” on pa

Lenovo Y480/Y580 Hardware Maintenance Manual68Figure 16. Removal steps of LCD panel, LCD cable and hinges (continued)Y480: Remove six screws and the

Lenovo Y480/Y58069Figure 16. Removal steps of LCD panel, LCD cable and hinges (continued)Y580: Remove eight screws . Lift the LCD panel with hinges i

Lenovo Y480/Y580 Hardware Maintenance Manual701170 Integrated cameraFor access, remove these FRUs in order:• “1010 Battery pack” on page 35• “1020 Dum

Lenovo Y480/Y58071Front viewIntegrated cameraBuilt-in microphoneComputer displayJBL speakersPower buttonOneKey Rescue system buttonOneKey Theater butt

Lenovo Y480/Y580 Hardware Maintenance Manual72Right-side viewAC power adapter jackUSB portOptical driveTV-in jack (On select models)Microphone jackHea

Lenovo Y480/Y58073Bottom and Left-side viewKensington slotFan louversVGA portRJ-45 portHDMI portUSB portBattery latch - manualBattery packBattery latc

Lenovo Y480/Y580 Hardware Maintenance Manual74This section presents the following service parts:• “Overall” on page 75• “LCD FRUs” on page 84• “Keyboa

Lenovo Y480/Y58075OverallY580Y580Y480Y480Y480Y580Y480Y480Y58016713ii5342215h171820de12g910111416192021233b24a22fc988

Lenovo Y480/Y580 Hardware Maintenance Manual4• Always look carefully for possible hazards in your work area. Examples of these hazards are moist floor

Lenovo Y480/Y580 Hardware Maintenance Manual76Table 5. Parts list—OverallNo. FRU FRU no. CRU ID1 LCD unit (see “LCD FRUs” on page 84.)2 Keyboard (see

Lenovo Y480/Y58077Table 5. Parts list—Overall (continued)No. FRU FRU no. CRU ID10 Processor,Ivy bridge core Quad-Core 35W,Intel I7-3612QM 2.1G E1 6M 4

Lenovo Y480/Y580 Hardware Maintenance Manual78Table 5. Parts list—Overall (continued)No. FRU FRU no. CRU ID10 Processor, Sandy bridge core Dual Core

Lenovo Y480/Y58079Table 5. Parts list—Overall (continued)No. FRU FRU no. CRU ID12 DDR3 1600 4GB, Hynix, HMT351S6CFR8C-PB DDR3 1600 4GB (Y580)11200344

Lenovo Y480/Y580 Hardware Maintenance Manual80Table 5. Parts list—Overall (continued)No. FRU FRU no. CRU ID16 TV Tuner Module, DMB-T, Geniatech, MM700

Lenovo Y480/Y58081Table 5. Parts list—Overall (continued)No. FRU FRU no. CRU ID18 Battery pack, 3S2P, 6cell 6400mAh 72Wh, LG, LG L11L6R01 3S2P 72Wh ba

Lenovo Y480/Y580 Hardware Maintenance Manual82Table 5. Parts list—Overall (continued)No. FRU FRU no. CRU ID21 Hard disk drive, 750G 5400rpm, Toshiba M

Lenovo Y480/Y58083Table 5. Parts list—Overall (continued)No. FRU FRU no. CRU ID21 Hard disk drive,1TB 5400rpm, WD WD10JPVT-24A1YT0 5400PRM 9.5mm 1T HD

Lenovo Y480/Y580 Hardware Maintenance Manual84LCD FRUsIn Lenovo Y480/Y580, there are following types of LCDs.• “14.0-in. HD TFT” Y480• “15.6-in. HD TF

Lenovo Y480/Y5808514.0-in. HD TFT (Y480)Table 6. Parts list—14.0-in. HD TFTNo. FRU FRU no. CRU ID1 QIWY3 LCD Bezle W/Camera Y480 90200412 N2 QIWY3 LCD

Safety information5The purpose of this inspection guide is to assist you in identifying potential unsafe conditions. As each machine was designed and

Lenovo Y480/Y580 Hardware Maintenance Manual8614.0-in. HD TFT (Y580)Table 6. Parts list—14.0-in. HD TFTNo. FRU FRU no. CRU ID1 QIWY4 LCD Bezle W/Camer

Lenovo Y480/Y58087KeyboardTable 8. Parts list—KeyboardLanguage P/N CRU IDY480Chicony (Black)English 25203154 **U.K. English 25203155 **Italian 2520315

Lenovo Y480/Y580 Hardware Maintenance Manual88Table 8. Parts list—KeyboardLanguage P/N CRU IDY480Chiccony (Backlight) (continued)Greek 25202960 **Hebr

Lenovo Y480/Y58089Table 8. Parts list—KeyboardLanguage P/N CRU IDY480Sunrex (Backlight)English 25202972 **U.K. English 25202973 **Italian 25202974 **S

Lenovo Y480/Y580 Hardware Maintenance Manual90Table 8. Parts list—KeyboardLanguage P/N CRU IDY480Darfon (Back) (continued)Greek 25203232 **Hebrew 2520

Lenovo Y480/Y58091Table 8. Parts list—KeyboardLanguage P/N CRU IDY580ChiconyEnglish 25203062 **U.K. English 25203063 **Italian 25203064 **Spanish 2520

Lenovo Y480/Y580 Hardware Maintenance Manual92Table 8. Parts list—KeyboardLanguage P/N CRU IDY580Darfon (continued)Greek 25203140 **Hebrew 25203141 **

Lenovo Y480/Y58093Miscellaneous partsTable 9. Parts list—Miscellaneous partsFRU P/N CRU IDSystem miscellaneous parts:• (a) QIWY3 HDD Bracket Y480• (a

Lenovo Y480/Y580 Hardware Maintenance Manual94AC adaptersTable 10. Parts list—3-pin AC adaptersFRU P/N CRU ID90W, Delta ADP-90DD BD 20V4.5A adapter 36

Lenovo Y480/Y58095Power cordsA Lenovo power cord for a specific country or region is usually available only in that country or region:Table 11. Parts